新聞中心
新聞資訊
聯系我們
山東途暢路橋工程有限公司
聯系人：石總
電話：18264104888
地址：山東省濟南市槐蔭區經一路273號群盛華城
穩定土路拌機和冷再生的區別
來源：http://www.kqj188.com/ 日期：2022-03-03 發布人：
冷再生機一次破碎拌合寬度為2.4米，工作時經常會有一輛水罐車緊跟作業保證拌合用水，拌合過程中按照試驗單所規定的高于平時含水量，除此之外還需要有一輛水罐車需滿水隨時處于待命狀態，一旦跟再生機作業的水罐沒水了，需即刻補上。
The one-time crushing and mixing width of the cold regenerator is 2.4m. During operation, there is often a water tanker following the operation to ensure the mixing water. During the mixing process, the water content is higher than that specified in the test sheet. In addition, a water tanker needs to be full of water and on standby at any time. Once there is no water in the water tank working with the regenerator, it needs to be replenished immediately.
冷再生機出租的時候需要進行對再生混合料拌，應立即用平地機初步整形。在直線和不設高的平曲線段，平地機由路肩向中間進行刮平。很多冷再生機出租的時候，都會面對這點，對路面的平整過程中應及時去除粗細料離析現象。既由人工配合機械把大塊沒有破碎掉的舊路料清理掉。冷再生機租賃時候一般行走比較困難，則需先由冷再生機對舊路面層進行銑刨后，在破碎料上再鋪水泥，進行冷再生拌合施工。
When the cold regenerator is rented, it is necessary to mix the recycled mixture, and the grader shall be used for preliminary shaping immediately. In straight lines and flat curve sections without height, the grader scrapes from the shoulder to the middle. Many cold recycling machines will face this when renting. The segregation of coarse and fine materials should be removed in time in the process of road leveling. The large old road materials that have not been broken shall be cleaned up manually and mechanically. When renting the cold recycling machine, it is generally difficult to walk, so it is necessary to mill the old pavement layer by the cold recycling machine first, and then pave cement on the broken material for cold recycling mixing construction.
路拌（穩定土路拌機） 和 冷再生（路面冷再生機）的 區別？
What is the difference between road mixing (stabilized soil road mixer) and cold recycling (pavement cold recycling machine)?
一、用途不同
1、 Different uses
1、路面冷再生機：對舊瀝青路面進行修正。
1. Pavement cold recycling machine: modify the old asphalt pavement.
2、穩定土拌和機：穩定土拌和機主要用于公路工程施工中，完成穩定土基層的現場拌和作業。
2. Stabilized soil mixer: the stabilized soil mixer is mainly used in highway engineering construction to complete the on-site mixing of stabilized soil base.
二、特點不同
2、 Different characteristics
1、路面冷再生機：采用大功率中冷增壓發動機，功率儲備系數高，動力強勁；液壓系統采用國際液壓泵和馬達；工作速度、控制灑水量。
1. Road cold regenerator: it adopts high-power intercooled supercharged engine, with high power reserve coefficient and strong power; The hydraulic system adopts international brand hydraulic pump and motor; Work speed and control the amount of water sprayed.
2、穩定土拌和機：功率大、耗油低、可靠性高。
2. Mixer: high power and reliability.
三、工作方式不同
3、 Different working methods
1、路面冷再生機：作業時在對舊瀝青路面進行銑刨、破碎的同時，添加穩定劑（水泥、石灰、水等），就地拌和通過整形、壓實而形成新的道路基層。
1. Pavement cold regenerator: during operation, while milling and crushing the old asphalt pavement, add stabilizer (cement, lime, water, etc.), mix in place, and form a new road base through shaping and compaction.
2、穩定土拌和機：其工作裝置對土壤就地松碎，并與穩定劑（石灰、水泥、瀝青、乳化瀝青或其他化學劑）均勻拌和，以提高土壤穩定性的機械。
2. Stabilized soil mixer: a machine whose working device crushes the soil on site and mixes it evenly with stabilizer (lime, cement, asphalt, emulsified asphalt or other chemical agents) to improve soil stability.
三、工作方式不同
3、 Different working methods
1、路面冷再生機：作業時在對舊瀝青路面進行銑刨、破碎的同時，添加穩定劑（水泥、石灰、水等），就地拌和通過整形、壓實而形成新的道路基層。
1. Pavement cold regenerator: during operation, while milling and crushing the old asphalt pavement, add stabilizer (cement, lime, water, etc.), mix in place, and form a new road base through shaping and compaction.
2、穩定土拌和機：其工作裝置對土壤就地松碎，并與穩定劑（石灰、水泥、瀝青、乳化瀝青或其他化學劑）均勻拌和，以提高土壤穩定性的機械。
2. The asphalt mixer and other mechanical stabilizers are used to stabilize the soil uniformly and improve the stability of the soil by mixing the asphalt and crushed lime in situ.
以上就是為大家介紹的有關冷再生機租賃的詳細的介紹,希望對您有所幫助.如果您有什么疑問的話,歡迎聯系我們.我們將以的態度,為您提供服務http://www.kqj188.com
The above is a detailed introduction to the leasing of cold regenerator. I hope it will be helpful to you If you have any questions, please contact us We will provide you with professional service http://www.kqj188.com
推薦閱讀/ Recommended reading
- 撒布精度±5%是怎么做到的？ 2026-07-29
- 水泥撒布車三種類型怎么選？ 2026-07-27
- 水泥撒布車出租基礎知識與核心價值 2026-07-25
- 冷再生機租賃的市場趨勢與未來 2026-07-23
水泥撒布車出租避坑指南先注意這個5點
[2026-07-31]
水泥撒布車出租市場魚龍混雜，租錯了不僅浪費錢，還可能耽誤整個工期。以下5條避坑指南，幫你避開非常常見的“坑”。The rental market for cement spread...
