新聞中心
新聞資訊
聯系我們
山東途暢路橋工程有限公司
聯系人：石總
電話：18264104888
地址：山東省濟南市槐蔭區經一路273號群盛華城
對冷再生機維護要注意什么？
來源：http://www.kqj188.com/ 日期：2023-09-23 發布人：
合理的使用瀝青設備，使其潛力限度地發揮，是公路機械化施工企業之所求，而保養和維修是程度發揮機械效益的必 備前提。針對這種情況，我們?cè)跈C(jī)械管理上制訂并確定了每班保養內容，并督促實施。每月的月底進行瀝青設備強制保養2-3天，使很多故障在未出現前就被排除了。
The rational use of asphalt equipment to maximize its potential is the requirement of highway mechanized construction enterprises, and maintenance and repair are essential prerequisites for maximizing mechanical efficiency. In response to this situation, we have formulated and determined the maintenance content for each shift in mechanical management, and urged its implementation. At the end of each month, mandatory maintenance of asphalt equipment is carried out for 2-3 days, which eliminates many faults before they occur.
每天作業后應該清除瀝青設備內的殘余水泥混凝土，使拌刀磨損減小，延長了拌刀使用壽命;清除整機所有器件的塵土，對潤滑部位加注黃油，使整機潤滑部件的潤滑情況良好，減小了易損件的磨損，從而減少了因磨損而出現的機械故障;檢查各緊固件及易損件，發現問題及時予以解決，使有些故障排除在未出現以前，做到防患于未然;能堅持每班保養，瀝青設備使用壽命平均可延長工作時間800h，拌刀可延長600h。
After daily operations, residual cement concrete should be removed from the asphalt equipment to reduce wear and prolong the service life of the mixing blade; Remove dust from all components of the entire machine, add grease to the lubrication parts, ensure good lubrication of the lubrication components of the machine, reduce wear on vulnerable parts, and thus reduce mechanical failures caused by wear; Check all fasteners and vulnerable parts, and promptly solve any problems found, so that some faults can be eliminated before they occur, so as to prevent problems before they occur; Being able to maintain every shift, the average service life of asphalt equipment can be extended by 800 hours, and the mixing blade can be extended by 600 hours.
1、冷再生出租技術具有適用性。早期路面診斷是非常必要的。水泥冷再生技術一般是原路面的突出、調平、突出、分層等施工技術。僅是淺層路面結構的再生（不大于25cm），對于路面結構下層的病害沒有修復作用。對于路面基層承載力不足，彎沉值過大等情況下需要恢復路面功能的深度處理，一個簡單的一層冷再生工藝不能起到有效強化結構層的作用。
1. The cold regeneration rental technology has applicability. Early road surface diagnosis is very necessary. Cement cold recycling technology generally refers to the construction techniques of rolling, leveling, rolling, and layering of the original road surface. The regeneration of only shallow pavement structures (not greater than 25cm) has no repair effect on the diseases in the lower layer of the pavement structure. For situations where the bearing capacity of the pavement base is insufficient and the deflection value is too large, a simple one layer cold regeneration process cannot fully strengthen the structural layer, which requires deep treatment to restore the pavement function.
2、水泥用量的確定將直接影響到再生層質量。適當?shù)乃鄤┝坎粌H可以避免因水泥劑量不足引起的乏力，還能減少過度的水泥劑量引起的基底應力收縮裂縫，延長道路的使用壽命。
2. The determination of cement dosage will directly affect the quality of the recycled layer. An appropriate cement dosage can not only avoid fatigue caused by insufficient cement dosage, but also reduce base stress shrinkage cracks caused by excessive cement dosage, extending the service life of the road.
3、水泥的選擇是非常重要的。水泥的冷再生不需要使用明顯水泥。它有嚴格的要求。水泥粘結劑的要求基本相同，青島冷再生機，水泥穩定碎石。它需要延緩水泥初凝時間大于3h，終凝時間大于6小時的緩凝水泥。
3. The choice of cement is very important. The cold regeneration of cement does not require the use of any cement. It has strict requirements. The requirements for cement binder are basically the same, with Qingdao cold recycling machine and cement stabilized crushed stone. It requires delayed cement with an initial setting time greater than 3 hours and a final setting time greater than 6 hours.
4、施工用水的選擇。看似微不足道的因素，但可能是由于過多的雜質或鹽離子過多的施工用水，造成質量問題。
4. Selection of construction water. A seemingly insignificant factor, but it may be due to excessive impurities or salt ions in construction water, resulting in quality issues.
5、施工設備選型施工設備，施工設備其中包括再生機、壓路機等，因其不同的性能會影響到整個工程的質量和效率，因此有必要選用操作智能，性能優越的施工設備確保施工各環節的內在質量。
5. Construction equipment selection includes regeneration machines, road rollers, etc. Due to their different performance, which can affect the quality and efficiency of the entire project, it is necessary to choose construction equipment with intelligent operation and superior performance to ensure the internal quality of each construction link.
6、養生。有許多方法來保持健康：噴灑透層瀝青、灑水、覆蓋塑料薄膜等，養生期間斷絕或限制交通。
6. Health preservation. There are many ways to maintain health: spraying a layer of asphalt, watering, covering with plastic film, etc., and cutting off or restricting traffic during the health period.
推薦閱讀/ Recommended reading
- 水泥撒布車出租：撒灰車常見故障排除 2026-08-05
- 冷再生拌合機節能降耗技巧有哪些？ 2026-08-05
- 水泥撒布車出租避坑指南先注意這個5點 2026-07-31
- 撒布精度±5%是怎么做到的？ 2026-07-29
撒灰車開啟道路建設新篇章
[2026-08-07]
在當前的交通建設領域，創新技術的應用正不斷推動著行業的進步與發展。其中，撒灰車作為一種新型工程車輛，憑借其便捷的特點，在公路、鐵路、機場道路建設等領域展現出了強大的應用潛力。In...
